2016 Hyundai Santa FE problems & reliability
235 owner complaints filed with NHTSA for the 2016 Hyundai Santa FE, alongside 3 safety recall campaigns. Last verified Aug 7, 2026. Complaints are unverified reports submitted by owners to the federal Office of Defects Investigation.
Each complaint is counted once (by NHTSA case number), even when it names several vehicles.
5 complaints report injuries (6 injured).
Federal crash records (FARS 2020–2023): 2016 Hyundai Santa FE vehicles were involved in 43 fatal crashes with 24 occupant deaths. Involvement counts are not adjusted for how many are on the road and do not imply fault or a vehicle defect.
Most reported problems
| Component | Complaints | Share |
|---|---|---|
| Engine | 150 | 64% |
| Unknown OR Other | 25 | 11% |
| Power Train | 20 | 9% |
| Electrical System | 11 | 5% |
| Air Bags | 9 | 4% |
| Service Brakes, Hydraulic | 9 | 4% |
| Fuel/propulsion System | 8 | 3% |
| Seat Belts | 8 | 3% |
| Service Brakes | 8 | 3% |
| Structure | 6 | 3% |
Component groups as classified by NHTSA. A complaint can name more than one component, so shares may sum to more than 100%.
Common symptoms owners describe
Keyword analysis of complaint narratives; one complaint can describe several symptoms.
Mileage when problems occurred
Half of the failures with a reported odometer reading occurred by 62,300 miles (middle 50% between 19,450 and 87,000 miles), based on 67 complaints that included mileage.
Complaints by incident year
What owners report
“WHAT FAILED: The engine — the 3.3L Lambda II GDI V6 (engine family GHYXV03.31XE per the federal emissions label) — failed catastrophically: a connecting rod penetrated the engine block. The failed engine IS available for inspection on request. It has been preserved unrepaired since the failure, the rod penetration of…”
Engine · filed Jun 11, 2026
“I filed a complaint when the first engine seized. It's a miracle we got off the road safely that day. While it was at the dealership, the engine was replaced with a used engine and covered by my extended warranty from Vroom. I believe the cost was approximately $14,000. I was told the engine had around 30,000 miles on…”
Engine · filed Jun 6, 2026
“Purchased a used Santa Fe in January 2026 with 129k mile and at 131k my vehicle's CEL came on and did not function properly while operating. While driving the vehicle failed to accelerate above 25 mph when I pushed the gas. I pulled over to get out of the way of traffic and avoid any accidents. I shut the car off and…”
Engine · filed May 25, 2026
Verbatim excerpts from complaints filed with NHTSA. Reports are not independently verified.
Federal defect investigations
- Hyundai and Kia ABS Module Fires
Audit Query AQ23002 · opened Nov 17, 2023 · open
- Loss of Motive Power
Defect Petition DP22003 · opened Sep 12, 2022 · closed Dec 12, 2023
- Throttle control system vulnerabilities
Defect Petition DP21003 · opened Nov 12, 2021 · closed Jun 20, 2023
Technical service bulletins
111 manufacturer communications (TSBs, service campaigns, warranty extensions) are on file with NHTSA for the 2016 Hyundai Santa FE. The 10 most recent:
Certain 2012 – 2017 model year Accent, 2012 – 2017 model year Azera, 2013 – 2018 model year Santa Fe Sport, 2013 – 2019 model year Santa Fe, and 2012 – 2017 model year Veloster vehicles may exhibit an intermittent…
Z01 Letter · Warranty Program/Extension · issued May 23, 2026
Some vehicles listed below may exhibit an intermittent airbag warning light and DTC(s) B1763 (OCS ECU Defect), and/or B1764 (OCS Mat Defect) may be stored. Hyundai is extending the warranty coverage of the sensor for…
26-BE-011H DN · Warranty Program/Extension · issued Apr 25, 2026
Some vehicles listed below may exhibit an intermittent airbag warning light and DTC(s) B1763 (OCS ECU Defect), and/or B1764 (OCS Mat Defect) may be stored. Hyundai is extending the warranty coverage of the sensor for…
26-BE-011H TSB · Warranty Program/Extension · issued Apr 25, 2026
The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co.…
DTN DL · Other · issued Apr 10, 2026
The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety…
DTN DCS · Other · issued Apr 10, 2026
Certain Santa Fe / Santa Fe XL (NC) vehicles equipped with 3.3L Lambda II GDI engines may exhibit abnormal engine noise or damage. Technical Service Bulletin (TSB) 26-EM-002H describes the procedure to inspect the…
26-EM-002H DCS · Warranty Program/Extension · issued Feb 11, 2026
Certain Santa Fe / Santa Fe XL (NC) vehicles equipped with 3.3L Lambda II GDI engines may exhibit abnormal engine noise or damage. This bulletin describes the procedure to inspect the engine and perform the proper…
26-EM-002H TSB · Warranty Program/Extension · issued Feb 11, 2026
Certain Santa Fe / Santa Fe XL (NC) vehicles equipped with 3.3L Lambda II GDI engines may exhibit abnormal engine noise or damage. This service procedure describes to inspect the engine and perform the proper repair…
26-EM-002H DN · Warranty Program/Extension · issued Feb 11, 2026
In response to this trend, we engineered a software upgrade that addresses the social media theft method and made it available to owners of eligible models free of charge at authorized Hyundai dealers since early 2023…
P33 OL · Other · issued Dec 19, 2025
Upon customer's request ONLY, the Technical Service Bulletin (TSB) 25-01-089H provides the service procedure for installation of a key cylinder reinforcement protector assembly and two anti-theft decals on the front…
25-01-089H DCS · Other · issued Dec 15, 2025
TSBs are repair guidance manufacturers send to dealers — they are not recalls and repairs are not automatically free. Full documents are available on NHTSA’s site.
Safety recalls
The 2016 Hyundai Santa FE has 3 NHTSA recall campaigns — recall repairs are free at franchised dealers regardless of the vehicle’s age.
Check whether your specific vehicle is affected
Recall campaigns often cover only certain VIN ranges. Enter your VIN on the official NHTSA site to confirm whether your vehicle is included and whether the repair is still open.
Check VIN on NHTSA →Buying a used 2016 Hyundai Santa FE?
- · Decode the seller’s VIN with our free VIN decoder to confirm the exact year, engine and trim.
- · Check for unrepaired recalls by VIN on NHTSA’s official lookup — recall repairs are free.
- · Owners most often reported problems around 62,300 miles — budget accordingly if the car is approaching that mileage.