2007 Chevrolet Silverado 3500 problems & reliability
39 owner complaints filed with NHTSA for the 2007 Chevrolet Silverado 3500, alongside 5 safety recall campaigns. Last verified Aug 7, 2026. Complaints are unverified reports submitted by owners to the federal Office of Defects Investigation.
Each complaint is counted once (by NHTSA case number), even when it names several vehicles.
2 complaints report injuries (2 injured).
Most reported problems
| Component | Complaints | Share |
|---|---|---|
| Air Bags → | 12 | 31% |
| Engine and Engine Cooling | 5 | 13% |
| Steering | 4 | 10% |
| Engine | 3 | 8% |
| Fuel System, Diesel | 3 | 8% |
| Power Train | 3 | 8% |
| Service Brakes | 3 | 8% |
| Electrical System | 2 | 5% |
| Back Over Prevention | 1 | 3% |
| Fuel/propulsion System | 1 | 3% |
Component groups as classified by NHTSA. A complaint can name more than one component, so shares may sum to more than 100%.
Common symptoms owners describe
Keyword analysis of complaint narratives; one complaint can describe several symptoms.
Mileage when problems occurred
Half of the failures with a reported odometer reading occurred by 41,000 miles (middle 50% between 24,065 and 76,000 miles), based on 23 complaints that included mileage.
Complaints by incident year
What owners report
“The contact owned a 2007 Chevrolet Silverado. The contact stated that while driving at 65 MPH, the contact noticed smoking coming from the under the front vehicle. The contact mention he pulled over the right side of the road, turned the vehicle off and then exited the vehicle and opened the hood of the vehicle and…”
Engine · filed Jun 3, 2026
“I purchased my new 2007 Chevy duramax diesel with an already installed fabtech lift kit. My pitman arm has snapped 3 times since I purchased my truck leaving me with complete steering loss. I have had to replace all steering components several times. My truck is unsafe due to a fabtech lift kit that the dealer…”
Steering · filed Dec 16, 2024
“Tl* the contact owns a 2007 chevrolet silverado 3500. The contact stated that while refueling, diesel fuel sprayed back out of the filler neck. The contact was concerned that the design of the filler neck to the fuel tank was defective. A dealer was not contacted. The vehicle was not diagnosed nor repaired. The…”
Fuel System, Diesel · filed Aug 14, 2020
Verbatim excerpts from complaints filed with NHTSA. Reports are not independently verified.
Federal defect investigations
- Desiccated Air Bag Inflator Rupture
Engineering Analysis EA21002 · opened Sep 17, 2021 · open
- NON-CRASH ENGINE COMPARTMENT FIRES
Engineering Analysis EA08010 · opened Jun 12, 2008 · closed Sep 8, 2008 · led to recall 08V441000
- NON-CRASH ENGINE COMPARTMENT FIRES
Preliminary Evaluation PE08010 · opened Feb 4, 2008 · closed Jun 12, 2008
Technical service bulletins
499 manufacturer communications (TSBs, service campaigns, warranty extensions) are on file with NHTSA for the 2007 Chevrolet Silverado 3500. The 10 most recent:
This Preliminary Information communication provides information to the technician that some owners of Heavy Duty Trucks and Utilities may ask if they can lower their tire pressures. Tire pressures being set to the "Tire…
PIT4506J · Service Bulletin/Repair Instructions · issued Feb 16, 2026
This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may…
PIC5650M · Service Bulletin/Repair Instructions · issued Aug 7, 2025
This Preliminary Information communication provides information to the technician about vehicles that may have a bump feel or clunk noise at a stop or on launch. Dealer should communicate to the customer this condition…
PIT5161L · Service Bulletin/Repair Instructions · issued Jul 31, 2025
This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
PIP5601C · Service Bulletin/Repair Instructions · issued Jul 18, 2025
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
PIT5074R · Service Bulletin/Repair Instructions · issued May 30, 2025
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
PIT5074R · Service Bulletin/Repair Instructions · issued May 30, 2025
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
PIT5074R · Service Bulletin/Repair Instructions · issued May 30, 2025
This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
23-NA-001 · Service Bulletin/Repair Instructions · issued Mar 28, 2025
This Preliminary Information communication provides information to the technician that some owners of Heavy Duty Trucks and Utilities may ask if they can lower their tire pressures. Tire pressures being set to the "Tire…
PIT4506H · Service Bulletin/Repair Instructions · issued Feb 21, 2025
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or…
PIP5358D · Service Bulletin/Repair Instructions · issued Feb 20, 2025
TSBs are repair guidance manufacturers send to dealers — they are not recalls and repairs are not automatically free. Full documents are available on NHTSA’s site.
Safety recalls
The 2007 Chevrolet Silverado 3500 has 5 NHTSA recall campaigns — recall repairs are free at franchised dealers regardless of the vehicle’s age.
Check whether your specific vehicle is affected
Recall campaigns often cover only certain VIN ranges. Enter your VIN on the official NHTSA site to confirm whether your vehicle is included and whether the repair is still open.
Check VIN on NHTSA →Buying a used 2007 Chevrolet Silverado 3500?
- · Decode the seller’s VIN with our free VIN decoder to confirm the exact year, engine and trim.
- · Check for unrepaired recalls by VIN on NHTSA’s official lookup — recall repairs are free.
- · Owners most often reported problems around 41,000 miles — budget accordingly if the car is approaching that mileage.