2009 MINI Cooper Clubman problems & reliability
39 owner complaints filed with NHTSA for the 2009 MINI Cooper Clubman, alongside 1 safety recall campaign. Last verified Aug 7, 2026. Complaints are unverified reports submitted by owners to the federal Office of Defects Investigation.
Each complaint is counted once (by NHTSA case number), even when it names several vehicles.
1 complaint report injuries (1 injured).
Most reported problems
| Component | Complaints | Share |
|---|---|---|
| Engine → | 11 | 28% |
| Air Bags → | 10 | 26% |
| Electrical System | 8 | 21% |
| Power Train | 5 | 13% |
| Structure | 4 | 10% |
| Engine and Engine Cooling | 3 | 8% |
| Unknown OR Other | 3 | 8% |
| Fuel/propulsion System | 2 | 5% |
| Seats | 2 | 5% |
| Steering | 2 | 5% |
Component groups as classified by NHTSA. A complaint can name more than one component, so shares may sum to more than 100%.
All 16 reported components →Common symptoms owners describe
Keyword analysis of complaint narratives; one complaint can describe several symptoms.
Mileage when problems occurred
Among the 28 complaints that included a usable odometer reading, the median reported incident mileage was 71,000 miles (middle 50% between 56,066 and 86,250 miles).
Complaints by incident year
What owners report
“I received a recall notice from MINI USA dated July 2023. The recall issue date is in May 2023. The notice states the Footwell Control Module (FRM) can become corroded and can increase the risk of fire or injury. The letter states they do not have a remedy available, but one is in development. That was over a year ago…”
Unknown OR Other · filed Oct 30, 2024
“The contact owned a 2009 Min Cooper Clubman. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time…”
Electrical System · filed Oct 29, 2024
“The driver's side footwell is continuously full of water for the past several years. During rain water runs inside the car, from somewhere behind the dash, into the driver's footwell. The Footwell Control Module (FRM) is in water and is actively corroding. The Footwell Control Module is an electronic control unit…”
Electrical System · filed Aug 24, 2024
Verbatim excerpts from complaints filed with NHTSA. Reports are not independently verified.
Technical service bulletins
79 manufacturer communications (TSBs, service campaigns, warranty extensions) are on file with NHTSA for the 2009 MINI Cooper Clubman. The 10 most recent:
MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can…
M610607 · Service Bulletin/Repair Instructions · issued Oct 25, 2023
New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. These new wheel electronics will need to be programmed using the new tool…
M360119 · Service Bulletin/Repair Instructions · issued Dec 1, 2021
OC3 SEAT OCCUPANCY MAT - LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES: Component-Specific Limited Warranty Extension For the above-referenced vehicles, MINI USA, a division of BMW of North America, LLC (MINI…
M011116 · Service Bulletin/Repair Instructions · issued Aug 1, 2020
CLASS ACTION SETTLEMENT: N14 HIGH-PRESSURE FUEL PUMP (HDP) SERVICE BENEFIT CLASS VEHICLES: The MINI vehicle may experience a sudden engine operational failure reduced or loss of power while driving and the malfunction…
M010419 · Service Bulletin/Repair Instructions · issued Jan 1, 2020
Air Conditioning System Leak Testing. The customer complains of poor or no air conditioning cooling. After further diagnosis, the system is found to be low or empty of a refrigerant charge, but when using an electronic…
M640108 · Service Bulletin/Repair Instructions · issued Jul 12, 2019
Service Action: Checking or Replacing the Door Sill Trim Strips. The door sill trim strips are deformed and/or peeling up at the corners. CAUSE: Insufficient surface preparation of the door sill.
M510912 · Service Bulletin/Repair Instructions · issued Jul 12, 2019
Oc3 seat occupancy mat: limited warranty extension to 10 years/120.
M011116 · Service Bulletin/Repair Instructions · issued Jan 1, 2019
"MANUAL TRANSMISSION - STIFF DIAGONAL GEARSHIFT LEVER MOVEMENT. The customer may complain of a ""stiff diagonal shift"" (e.g., N-R, R-N, 2-3/3-2 or 4-5/5-4). Also, in some cases, gears cannot be selected, or the…
M230108 · Service Bulletin/Repair Instructions · issued Nov 1, 2018
Aisin automatic transmisison: right side output shaft seal replacement
M240118 · Service Bulletin/Repair Instructions · issued Feb 1, 2018
Automatic Deactivation of Recirculation Mode. The customer states the recirculation display goes out, even though the recirculation button was switched on. CAUSE The automatic recirculation air deactivation feature was…
M640114 · Service Bulletin/Repair Instructions · issued Aug 1, 2017
TSBs are repair guidance manufacturers send to dealers — they are not recalls and repairs are not automatically free. Full documents are available on NHTSA’s site.
Safety recalls
The 2009 MINI Cooper Clubman has 1 NHTSA recall campaign — recall repairs are free at franchised dealers regardless of the vehicle’s age.
Check whether your specific vehicle is affected
Recall campaigns often cover only certain VIN ranges. Enter your VIN on the official NHTSA site to confirm whether your vehicle is included and whether the repair is still open.
Check VIN on NHTSA →Buying a used 2009 MINI Cooper Clubman?
- · Decode the seller’s VIN with our free VIN decoder to confirm the exact year, engine and trim.
- · Check for unrepaired recalls by VIN on NHTSA’s official lookup — recall repairs are free.
- · Among complaints with usable mileage, the median reported incident mileage was 71,000 miles. This does not predict when a particular vehicle will develop a problem.