2005 Mercedes-Benz AMG E55 problems & reliability
132 owner complaints filed with NHTSA for the 2005 Mercedes-Benz AMG E55, alongside 3 safety recall campaigns. Last verified Aug 7, 2026. Complaints are unverified reports submitted by owners to the federal Office of Defects Investigation.
Each complaint is counted once (by NHTSA case number), even when it names several vehicles.
Most reported problems
| Component | Complaints | Share |
|---|---|---|
| Fuel/propulsion System | 75 | 57% |
| Fuel System, Gasoline | 62 | 47% |
| Electrical System | 3 | 2% |
| Engine | 2 | 2% |
| Air Bags | 1 | 1% |
| Power Train | 1 | 1% |
| Seats | 1 | 1% |
| Service Brakes | 1 | 1% |
| Service Brakes, Hydraulic | 1 | 1% |
| Suspension | 1 | 1% |
Component groups as classified by NHTSA. A complaint can name more than one component, so shares may sum to more than 100%.
Mileage when problems occurred
Half of the failures with a reported odometer reading occurred by 66,900 miles (middle 50% between 51,625 and 87,750 miles), based on 122 complaints that included mileage.
Complaints by incident year
What owners report
“Fuel pump housing failed allowing gas to leak, further degrading parts of the fuel system, ultimately causing the locking ring to fail and gas to leak under rear passenger seat. Fumes filled the cabin while my family and I including two young children were inside. Fortunately, this issue was discovered rather quick…”
Fuel/propulsion System · filed Jul 7, 2024
“The contact owns a 2005 Mercedes-Benz E55 AMG. The contact stated that after refueling the vehicle and arriving to the residence; the contact became aware that after parking the vehicle in the garage, there was an abnormally strong gasoline odor coming from the vehicle. Additionally, the contact saw fuel leaking from…”
Fuel System, Gasoline · filed Jun 26, 2024
“Mercedes benz of fort washington has denied a replacement of sbc unit and components under a safety recall. I lost brakes while driving. 'decreased brakes power' red message appeared”
Service Brakes · filed Dec 17, 2020
Verbatim excerpts from complaints filed with NHTSA. Reports are not independently verified.
Federal defect investigations
- Fuel Leakage From The Fuel Tank
Engineering Analysis EA13003 · opened Mar 15, 2013 · closed Dec 19, 2014
- Fuel System (Tank/Sender) Leakage
Preliminary Evaluation PE12001 · opened Jan 23, 2012 · closed Mar 18, 2013
- Driver Air Bag Circuit High Resistance
Preliminary Evaluation PE10017 · opened May 14, 2010 · closed Nov 24, 2010
Technical service bulletins
77 manufacturer communications (TSBs, service campaigns, warranty extensions) are on file with NHTSA for the 2005 Mercedes-Benz AMG E55. The 10 most recent:
Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end). The noise is heard once in each instance when changing direction of travel. Note: Sound file in attachment Cause…
LI35.30-P-058566 · Service Bulletin/Repair Instructions · issued Jul 14, 2026
Complaint There are several types of complaint about noises or poor windshield wiper wiping performance: A: Wiper blades squeaking, chattering, shuddering B: The windshield is not wiped completely (streaking) C: During…
LI82.30-P-059239 · Service Bulletin/Repair Instructions · issued May 19, 2026
Complaint Headlamp, front fog lamp leaky or fogged. Cause Fogging of the headlamps is a natural phenomenon, which can occur under certain climatic conditions. It does not lead to any technical impairment of the…
LI82.10-P-078301 · Service Bulletin/Repair Instructions · issued Apr 16, 2026
Complaint Headlamp, front fog lamp leaky or fogged Cause Fogging of the headlamps is a natural phenomenon, which can occur under certain climatic conditions. It does not lead to any technical impairment of the headlamp…
LI82.10-P-078301 · Service Bulletin/Repair Instructions · issued Mar 9, 2026
Complaint Headlamps leaking or fogged Cause The fogging of the headlamp is a natural phenomenon which can occur under certain climatic conditions. In contrast to a leaky headlamp, physical fogging does not result in a…
LI82.10-P-078307 · Service Bulletin/Repair Instructions · issued Feb 25, 2026
Complaint Headlamps leaking or fogged Cause The fogging of the headlamp is a natural phenomenon which can occur under certain climatic conditions. In contrast to a leaky headlamp, physical fogging does not result in a…
LI82.10-P-078896 · Service Bulletin/Repair Instructions · issued Feb 24, 2026
Complaint Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end). The clunk is heard once when changing from forward to reverse (and vice versa). Note: Sound file in…
LI33.30-P-056665 · Service Bulletin/Repair Instructions · issued Nov 15, 2025
Complaint Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end). The clunk is heard once when changing from forward to reverse (and vice versa). Note: Sound file in…
LI33.30-P-056665 · Service Bulletin/Repair Instructions · issued May 21, 2025
Complaint Headlamps leaking or fogged Cause The fogging of the headlamp is a natural phenomenon which can occur under certain climatic conditions. In contrast to a leaky headlamp, physical fogging does not result in a…
LI82.10-P-078896 · Service Bulletin/Repair Instructions · issued Apr 28, 2025
Complaint Headlamp, front fog lamp leaky or fogged Cause Fogging of the headlamps is a natural phenomenon, which can occur under certain climatic conditions. It does not lead to any technical impairment of the headlamp…
LI82.10-P-078301 · Service Bulletin/Repair Instructions · issued Apr 28, 2025
TSBs are repair guidance manufacturers send to dealers — they are not recalls and repairs are not automatically free. Full documents are available on NHTSA’s site.
Safety recalls
The 2005 Mercedes-Benz AMG E55 has 3 NHTSA recall campaigns — recall repairs are free at franchised dealers regardless of the vehicle’s age.
Check whether your specific vehicle is affected
Recall campaigns often cover only certain VIN ranges. Enter your VIN on the official NHTSA site to confirm whether your vehicle is included and whether the repair is still open.
Check VIN on NHTSA →Buying a used 2005 Mercedes-Benz AMG E55?
- · Decode the seller’s VIN with our free VIN decoder to confirm the exact year, engine and trim.
- · Check for unrepaired recalls by VIN on NHTSA’s official lookup — recall repairs are free.
- · Owners most often reported problems around 66,900 miles — budget accordingly if the car is approaching that mileage.