2020 Hyundai Tucson problems & reliability
176 owner complaints filed with NHTSA for the 2020 Hyundai Tucson, alongside 1 safety recall campaign. Last verified Sep 22, 2026. Complaints are unverified reports submitted by owners to the federal Office of Defects Investigation.
Each complaint is counted once (by NHTSA case number), even when it names several components.
4 complaints report injuries (5 injured).
Federal crash records (FARS 2020–2023): 2020 Hyundai Tucson vehicles were involved in 45 fatal crashes with 18 occupant deaths. Involvement counts are not adjusted for how many are on the road and do not imply fault or a vehicle defect.
Most reported problems
| Component | Complaints | Share |
|---|---|---|
| Engine → | 71 | 40% |
| Unknown / Other | 28 | 16% |
| Service Brakes → | 26 | 15% |
| Electrical System → | 19 | 11% |
| Service Brakes, Hydraulic → | 17 | 10% |
| Forward Collision Avoidance → | 12 | 7% |
| Power Train | 9 | 5% |
| Air Bags | 7 | 4% |
| Back Over Prevention | 7 | 4% |
| Lane Departure | 6 | 3% |
Component groups as classified by NHTSA. A complaint can name more than one component, so shares may sum to more than 100%.
All 22 reported components →Common symptoms owners describe
Keyword analysis of complaint narratives; one complaint can describe several symptoms.
Mileage when problems occurred
Among the 27 complaints that included a usable odometer reading, the median reported incident mileage was 11,332 miles (middle 50% between 4,500 and 71,000 miles).
Complaints by incident year
What owners report
“The contact owns a 2020 Hyundai Tucson. The contact stated that while the vehicle was receiving a routine oil change, the contact was informed that the oil pan was empty. The contact was advised to take the vehicle to the dealer. The contact was informed about a possible oil consumption test. The contact was informed…”
Engine · filed Aug 20, 2026
“Dealer completed update 9C2 Theta 2 emissions update. After update, the car sputters slightly and increased noise is heard from the tailpipe. Customer returned to dealer after driving the car in different temps and noted the above complaint. Dealer verified the complaint but continues to take no responsibility for the…”
Fuel/propulsion System · filed Aug 9, 2026
“The engine lost power while driving, and the vehicle entered a reduced-power mode. The check engine light began flashing, and the engine made a loud knocking noise during acceleration. A diagnostic scan showed code P1326 (Knock Sensor Signal Range/Performance). The knock sensor was replaced, and the engine oil was…”
Engine · filed Jul 28, 2026
Verbatim excerpts from complaints filed with NHTSA. Reports are not independently verified.
Federal defect investigations
- Hyundai and Kia ABS Module Fires
Audit Query AQ23002 · opened Nov 17, 2023 · open
Technical service bulletins
103 manufacturer communications (TSBs, service campaigns, warranty extensions) are on file with NHTSA for the 2020 Hyundai Tucson. The 10 most recent:
Certain vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension…
Z05 OL · Warranty Program/Extension · issued Aug 26, 2026
Certain Santa Fe (TMA), Santa Fe Sport (AN), Sonata (LFA), and Tucson (TL) vehicles equipped with Theta II engines may exhibit elevated engine-out emissions. The California Air Resources Board has determined that these…
26-01-013H-2 DN · Service Campaign · issued May 21, 2026
Certain Santa Fe (TMA), Santa Fe Sport (AN), Sonata (LFA), and Tucson (TL) vehicles equipped with Theta II engines may exhibit elevated engine-out emissions. This bulletin provides instructions for updating the Engine…
26-01-013H-2 TSB · Service Campaign · issued May 21, 2026
Following completion of Service Campaign 9C2 (Theta II Emissions Improvement), certain vehicles may exhibit a brief hesitation or rough shifting condition during cold start operation. If present, this condition is…
9C2 060518 · Service Campaign · issued May 19, 2026
Following completion of Service Campaign 9C2 (Theta II Emissions Improvement), certain vehicles may exhibit a brief hesitation or rough shifting condition during cold start operation. If present, this condition is…
9C2 DCS 260518 · Service Campaign · issued May 19, 2026
Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected…
26-BD-002H TSB · Warranty Program/Extension · issued Apr 28, 2026
Some Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected…
26-BD-002H DN · Warranty Program/Extension · issued Apr 28, 2026
Certain 2019 – 2020 model year Santa Fe, 2017 – 2018 model year Santa Fe Sport, 2015 – 2019 model year Sonata, and 2018 – 2021 model year Tucson vehicles may exhibit elevated engine-out emissions. Hyundai is conducting…
9C2 OL · Service Campaign · issued Apr 14, 2026
The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co.…
DTN DL · Other · issued Apr 10, 2026
The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety…
DTN DCS · Other · issued Apr 10, 2026
TSBs are repair guidance manufacturers send to dealers — they are not recalls and repairs are not automatically free. Full documents are available on NHTSA’s site.
Safety recalls
The 2020 Hyundai Tucson has 1 NHTSA recall campaign — recall repairs are free at franchised dealers regardless of the vehicle’s age.
Check whether your specific vehicle is affected
Recall campaigns often cover only certain VIN ranges. Enter your VIN on the official NHTSA site to confirm whether your vehicle is included and whether the repair is still open.
Check VIN on NHTSA →Buying a used 2020 Hyundai Tucson?
- · Decode the seller’s VIN with our free VIN decoder to confirm the exact year, engine and trim.
- · Check for unrepaired recalls by VIN on NHTSA’s official lookup — recall repairs are free.
- · Among complaints with usable mileage, the median reported incident mileage was 11,332 miles. This does not predict when a particular vehicle will develop a problem.