FAILURE OF ENGINE/TRANSMISSION MOUNT

What NHTSA is examining

On july 2, 2007 mazda north american operations submitted a defect information report to nhtsa regarding the left hand side (lhs) engine mount bolts in approximately 5,700 model year (my) 2007 mazdaspeed3 vehicles built from june 26, 2006 through may 19, 2007 (mazda recall 4607f, nhtsa recall 07v-295).according to mazda, the lhs engine mount could loosen under repeated loads produced during rapid accelerations.loose bolts could pull out or break, allowing the engine and transmission to drop on the left side.when the engine drops, the driveshaft may become detached and disable the vehicle.mazda will replace the lhs engine mount bolts in the recalled vehicles.in addition, the lhs engine mount rubber and bracket will be inspected and replaced if necessary.mazda stated in its letter that it continues to believe that there is no unreasonable risk of accident or injury associated with the condition, citing the lack of accidents and contending that most of the reported incidents were identified by operators before there was any effect on vehicle operation. Odi disagrees with mazda.although only about half the subject vehicles had entered service by the cutoff date of the failure data submitted by mazda, odi's analysis of consumer complaint and warranty claim data identified a total of 36 subject vehicles with repairs for loose or broken lhs mounting bolts.odi verified 17 incidents of bolt fracture resulting in the engine dropping in these vehicles, including at least 10 that…

Vehicles under investigation