ALTERNATOR FAILURE / ENGINE STALLING

What NHTSA is examining

Odi received 14 reports of alleged engine stalling due to alternator failure on my 2003-2004 murano (subject) vehicles.all of the complaints reported that the vehicle could not be restarted after the stall occurred.based on these complaints, odi opened pe04-077 and later upgraded to ea05-006 for the subject vehicles.during ea05-006, additional failure data were identified as noted in the failure report summary above.on july 12, 2005, nissan notified nhtsa of a safety defect on my 2003-2005 murano vehicles produced from april 8, 2002 and september 24, 2004 (recall 05v-319).the notification stated that an open circuit in the alternator can occur due to wire fatigue caused by movement of the rotor coil during rapid changes in engine speed in vehicles equipped with a continuously variable transmission (cvt).higher engine compartment temperature in the murano compared to other nissan models may also be a contributing factor to the wire fatigue.nissan also reported that when this happens, the charge warning and brake warning lamps will illuminate and the battery will begin to discharge.after a short time, the engine will then enter a fail safe mode that limits vehicle speed.very shortly after reaching this condition, the engine will stop.nhtsa's testing, however, showed that although the warning lamps illuminate, the vehicle speed is limited to only 4-7 mph rather than what nhtsa considers a fail safe mode. Nissan will instruct owners to return their vehicles to any nissan dealer…

Vehicles under investigation