2016 International Lonestar recalls
6 NHTSA recall campaigns naming the 2016 International Lonestar. Last verified Jul 30, 2026. Recalls may apply only to certain VIN ranges — always confirm with a VIN check.
Units are totals reported across campaigns mentioning this model — NHTSA does not always break unit counts down by model.
Affected components
Nearby model years
Check whether your specific vehicle is affected
Recall campaigns often cover only certain VIN ranges. Enter your VIN on the official NHTSA site to confirm whether your vehicle is included and whether the repair is still open.
Check VIN on NHTSA →Campaigns
- Nov 25, 2025Crash risk2016 International 7600, 2018 International 8600, 2025–2026 International HV and 5 other models — Service Brakes, Air
International Motors, LLC (International) is recalling certain 2016 7600, 2016-2023 Lonestar, 2018 8600, 2018-2023 LT, 2021-2026 MV, 2022-2023 RH, 2023-2026 HX, and 2025-2026 HV vehicles. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
25V817000 · 678 units · International Motors, LLC
- May 18, 2023Crash risk2004–2016 International 4400, 2000–2003 International 8100, 2002–2009 International 8500 and 12 other models — Exterior Lighting
Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
23V353000 · 33K units · Navistar, Inc.
- Sep 20, 2017Crash risk2016 IC Bus HC, 2016 International 9900I, 2016 International Durastar and 5 other models — Steering
Navistar, Inc. (Navistar) is recalling certain 2016 International DuraStar, LoneStar, ProStar, TerraStar, TranStar, WorkStar, 9900i, and IC Bus HC vehicles equipped with certain Spicer D or E series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
17V575000 · 1K units · Navistar, Inc.
- Oct 8, 2015Crash risk2016 International Durastar, 2016 International Lonestar, 2016 International Paystar and 1 other model — Electrical System
Navistar Inc. (Navistar) is recalling certain model year 2016 International ProStar trucks manufactured August 5, 2015, to August 14, 2015, DuraStar trucks manufactured August 7, 2015, to August 13, 2015, Paystar trucks manufactured August 11, 2015, to August 14, 2015, and LoneStar trucks manufactured August 10, 2015, to August 14, 2015. In the affected vehicles, the Engine Control Module (ECM) may short circuit, causing the engine to stall without warning.
15V631000 · 74 units · Navistar, Inc.
- May 29, 2015Crash risk2015–2016 International 9900, 2015–2016 International Lonestar — Engine and Engine Cooling
Navistar, Inc. (Navistar) is recalling certain model year 2015-2016 International 9900 trucks manufactured January 6, 2014, to March 12, 2015, and 2015-2016 International Lonestar trucks manufactured February 20, 2014, to March 13, 2015. The affected vehicles are equipped with a 6" diameter stack tail pipe, that may not have sufficient support. The unsupported weight of the upper stack tail pipe and vibration associated with normal vehicle operation over time may cause a crack of the weld joint between the inlet pipe and the flare expansion of the stack tail pipe, which may result in partial or full separation of the stack tail pipe from the vertical exhaust pipe.
15V329000 · 102 units · Navistar, Inc.
- Mar 23, 2015Fire risk2015 IC Bus CE, 2015–2016 International 9900, 2015–2016 International Durastar and 5 other models — Service Brakes, Air
Navistar, Inc. (Navistar) is recalling certain model year 2015-2016 International 9900, DuraStar, LoneStar, PayStar, ProStar, WorkStar and 2015 International TranStar and IC Bus CE vehicles equipped with a Haldex air braking system. The affected brake actuators may have been manufactured with an incomplete attachment of the internal rubber diaphragm to the actuation mechanism. This could cause dragging or overheated brakes.
15V165000 · 2K units · Navistar, Inc.