2015 Gillig Low Floor recalls
19 NHTSA recall campaigns naming the 2015 Gillig Low Floor. Last verified Jul 30, 2026. Recalls may apply only to certain VIN ranges — always confirm with a VIN check.
Units are totals reported across campaigns mentioning this model — NHTSA does not always break unit counts down by model.
Affected components
Nearby model years
Check whether your specific vehicle is affected
Recall campaigns often cover only certain VIN ranges. Enter your VIN on the official NHTSA site to confirm whether your vehicle is included and whether the repair is still open.
Check VIN on NHTSA →Campaigns
- Apr 25, 2022Crash risk2014–2021 Gillig Low Floor — Electrical System
Gillig, LLC (Gillig) is recalling certain 2014-2021 Low Floor transit buses. The rear-mounted ultracapacitors may allow the engine to be started when the master battery disconnect switch is in the "OFF" position.
22V276000 · 592 units · Gillig, LLC
- Jul 2, 2020Crash risk2013–2020 Gillig Low Floor — Steering
Gillig, LLC. (Gillig) is recalling certain 2013-2020 hybrid and all-electric Low Floor buses equipped with a steering system that uses a high-voltage electric motor and hydraulic pump assembly to provide power steering assist. The shaft coupling between the motor and pump may fail and cause a loss of hydraulic power steering assist.
20V392000 · 531 units · Gillig LLC
- Mar 25, 2020Fire risk2012–2020 Gillig Low Floor — Electrical System
Gillig LLC (Gillig) is recalling certain 2012-2020 Low Floor buses. The circuit breaker ratings on the DEF Line Heater circuit and the Aftertreatment-Ignition circuit may be higher than the rating for the wire and connector.
20V179000 · 8K units · Gillig LLC
- Mar 8, 2019Crash risk2014–2019 Gillig Low Floor — Exterior Lighting
Gillig LLC (Gillig) is recalling certain 2014-2019 Low Floor buses. Uncovered electrical terminals in the headlight power circuit may short circuit to ground, causing a loss of headlights.
19V193000 · 965 units · Gillig LLC
- Nov 9, 2018Crash risk2013–2018 Gillig Low Floor — Parking Brake
Gillig LLC (Gillig) is recalling certain 2013-2018 Gillig Low Floor transit buses equipped with disk brakes. The spring cage bolts on the air brakes may not be sufficiently tightened, reducing the effectiveness of the parking brake.
18V789000 · 4K units · Gillig LLC
- Aug 9, 2018Crash risk2012–2018 Gillig Low Floor — Exterior Lighting
Gillig LLC (Gillig) is recalling certain 2012-2018 Gillig Low Floor vehicles. The front and rear turn signals on these vehicles may flash at different rates, potentially confusing other drivers of the vehicle's intention. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
18V511000 · 178 units · Gillig LLC
- Jun 20, 2018Crash risk2001–2018 Gillig Low Floor — Exterior Lighting
Gillig LLC (Gillig) is recalling certain 2001-2018 Gillig Low Floor transit buses. The turn signals may flash slowly, reducing their visibility to other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
18V418000 · 26K units · Gillig LLC
- Sep 8, 2017Crash risk2013–2016 Gillig Low Floor — Steering
Gillig LLC (Gillig) is recalling certain 2013-2016 Hybrid and all Electric Low Floor buses with electro-hydraulic power steering assist. The coupler between the high-voltage electric motor and hydraulic steering pump shafts may fail, resulting in a loss of power steering assist.
17V559000 · 108 units · Gillig LLC
- Apr 19, 2017Crash risk2015–2016 Gillig Low Floor — Suspension
Gillig LLC (Gillig) is recalling certain 2015-2016 Low Floor transit buses equipped with Norgren-brand suspension kneeling modules. The suspension kneeling modules on these vehicles have snap rings on the solenoid valve pistons which may not have been fully inserted and seated during assembly, potentially affecting the suspension air bag pressure and the vehicle's suspension height.
17V263000 · 3K units · Gillig LLC
- Feb 24, 2017Crash risk1997–2017 Gillig Low Floor — Exterior Lighting
Gillig LLC (Gillig) is recalling certain model year 1997-2017 Low Floor transit buses. The front turn signals installed on standard profile (non-BRT) buses may not be sufficiently visible to other drivers or pedestrians. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
17V119000 · 17K units · Gillig LLC
- Dec 23, 2016Fire risk2015–2016 Gillig Low Floor — Fuel System, Other
Gillig LLC (Gillig) is recalling certain model year 2015-2016 Low Floor compressed natural gas (CNG) transit buses manufactured September 1, 2015, to December 5, 2016, equipped with Amerex SafetyNet fire suppression system panel/controller units. These buses have gas detection electronics that may be disabled without providing the operator with a warning of a system malfunction. Affected display panel/controller units were also provided as replacement parts for warranty claims, part numbers 16389, 24109, 24918, 24926 and 24927.
16V931000 · 451 units · Gillig LLC
- Sep 14, 2016Crash risk2014–2016 Gillig Low Floor — Service Brakes, Air
Gillig LLC (Gillig) is recalling certain model year 2014-2016 Gillig 29-foot Low Floor transit buses manufactured November 20, 2014, to February 11, 2016. These buses, equipped with disc brakes, have rear brake hoses that can rub chassis components and fray.
16V662000 · 34 units · Gillig LLC
- Jun 21, 2016Crash risk2012–2016 Gillig Low Floor — Exterior Lighting
Gillig LLC (Gillig) is recalling certain model year 2012-2016 Lowfloor diesel-electric hybrid vehicles manufactured March 6, 2012, to June 7, 2016. The affected vehicles are equipped with stop lamp activation that may inadvertently flash the rear brake lights. As such, these vehicles do not comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Assoc. Equipment."
16V451000 · 112 units · Gillig LLC
- Jan 13, 2016Crash risk2010–2015 Gillig Low Floor — Seats
Gillig LLC (Gillig) is recalling certain model year 2010-2015 Low Floor transit buses manufactured April 1, 2010 to October 30, 2015, equipped with Recaro Ergo-M Commercial Bus Driver Seats. The affected seats have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket.
16V011000 · 7K units · Gillig LLC
- Dec 30, 2015Crash risk2014–2015 Gillig Low Floor — Service Brakes, Hydraulic
Gillig LLC (Gillig) is recalling certain model year 2014-2015 Low Floor vehicles manufactured November 20, 2014, to June 2, 2015. The affected vehicles may be equipped with front brake chambers with an incorrect drain hole orientation. This can allow water to build up within the brake chamber, causing corrosion, deterioration, and reduce braking ability.
15V888000 · 16 units · Gillig LLC
- Jul 1, 2015Fire risk2010–2015 Gillig Low Floor — Electrical System
Gillig LLC (Gillig) is recalling certain model year 2010-2015 Low Floor transit buses manufactured April 13, 2010, to June 12, 2015. Due to the routing of the grid heater electrical power cable, the cable may chafe against a fuel injector hard line.
15V420000 · 7K units · Gillig LLC
- May 19, 2015Crash risk2014–2015 Gillig Low Floor — Exterior Lighting
Gillig LLC (Gillig) is recalling certain model year 2014-2015 Low Floor vehicles manufactured September 1, 2014, to April 30, 2015. The affected vehicles may have a taillight bracket that is inadequately bonded to the bus body.
15V295000 · 263 units · Gillig LLC
- May 5, 2015Fire risk2010–2015 Gillig Low Floor — Engine and Engine Cooling
Gillig LLC (Gillig) is recalling certain model year 2010-2015 Lowfloor vehicles manufactured August 26, 2010, to April 30, 2015. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
15V262000 · 1K units · Gillig LLC
- Apr 14, 2015Crash risk2013–2015 Gillig Low Floor — Service Brakes, Air
Gillig LLC (Gillig) is recalling certain model year 2013-2015 Low Floor transit buses manufactured July 8, 2013, to February 7, 2015 and equipped with disc brakes. The front left and right brake air hoses that connect to the brake chamber may touch and rub against the air bag suspension towers.
15V219000 · 623 units · Gillig LLC